Warranties on hot water systems vary depending on what system you have – the actual hot water cylinder itself will have a warranty of somewhere between five to ten years at most. Warranties on the electrics (thermostat and element) and valves (pressure relief, duo valve, etc) are usually 12 months. These are manufacturers warranties and apply to most systems.
Having said that, the average life of a hot water system is around 10-12 years although we have replaced systems that were more than 30 years old. It is a sad fact of life that sooner or later your hot water system will begin to leak from somewhere and the following gives you an idea of what it could be and what you can do about it.
There can be nothing more annoying than a leaking hot water system, particularly if the unit is located inside the home. There are only a few places that a hot water unit can leak from. The pressure and temperature relief valve (ptr valve) is located near the top on the unit and to one side of your hot water system and will have a small lever on it. This lever should be gently lifted approximately every six months or so to flush the valve free of accumulated debris. Be careful when you do this as hot water will come out of the relief line under pressure – keep all your valuable body parts out of the way!
After 10 seconds or so, gently let the lever back down and the flow will stop. The relief valve is designed to leak small amounts of water particularly on the heating cycle (after someone has had a shower for example) to stop the excessive build up of pressure inside the hot water system itself. These valves will eventually wear out and will need to be replaced. If you notice water running from the relief line on a regular basis the valve needs to be replaced. The longer you let it run the higher your electricity bill is going to be as the unit is constantly heating water even though you are not using it – hot water is running out the relief line on and cold water is coming in to the bottom of the tank to be heated continuously.
Another place a hot water unit can leak from is the element gasket. The element will be near the bottom of the hot water system where the electrical wires enter and is covered by a box or plate. The element has a rubber gasket around it where it penetrates the tank itself and these do perish over time which will cause leakage. Obviously, leaks from this area should be treated as a matter of urgency due to the close proximity of the leak to the electrical supply. Do not, under any circumstances try to fix this yourself – water and electricity do not mix and can make your hair curly – this is dangerous! The unit usually needs to be drained and the element removed to allow replacement of the gasket. Sometimes the area where the element bolts on to the tank is too corroded to allow the bolts to be tightened up enough to allow the new element gasket to get an effective seal. If this is the case the hot water stem will require replacement as there is no repair available for this problem. Always use a qualified tradesman when dealing with any aspect of your electricity system and supply – it simply is not worth risking your life for the sake of a few dollars.
Another place the unit can leak is from the cylinder itself. In the great majority of cases a leaking hot water cylinder means the unit is beyond repair and will also require replacement.
The average household plumbing system represents a large investment in the value of a house. No part of the house is more important. Nothing in the house is used more often. A smoothly functioning plumbing system is a pin to health and adds to the convenience of modern living nowadays.
These tips and hints were written with the objective of helping home owners as well as renters keep their hot water system in good operating condition. The sale value of a house with sound plumbing is far greater than that of a house where plumbing is in poor repair.
If you have an issue with a blocked drain Geelong or hot water system Geelong, then you need a 24 hour plumber Geelong, hot water Geelong or an emergency plumber Geelong to service you. You might also reach out to a gas plumber Geelong to help you. Its important that you have a plumber Geelong or drain camera Geelong, leaking tap Geelong, local plumber Geelong, roof plumber Geelong you can trust.
We provide service in and around Geelong. This includes: